Spohn GM07-1500-FLK Manuel d'utilisateur télécharger pdf

Spohn Performance, Inc.

494 E Lincoln Ave Myerstown, PA 17067

1-888-365-6064 www.spohn.net

Part# GM07-1500-FLK – 2.0” Front Leveling Lift Kit

2007-2013 GM 1500 Truck (4x4 & 4x2)

2007-2014 Suburban, Tahoe, Yukon, Avalanche & Escalade

USE OF THIS PRODUCT IS ACCEPTANCE OF SELLER’S DISCLAIMER OF WARRANTY!

By their very nature, competition components are constantly pushed to their limits. While our components

are designed to withstand intense race conditions, it is impossible to control the quality of installation or

the varying conditions in which they are used. It is for this reason that absolutely no warranty or

guarantee is either written or implied. Neither the seller or the manufacturer will be liable for any loss,

damage, or injury – direct or indirect – arising from the use of or inability to determine the use of any

product. Before using, the user should determine the suitability of the product for its intended use, and

the user shall assume all responsibility in connection therewith. Spohn Performance, Inc. makes no

guarantee as to the legality for any specific class. Spohn Performance, Inc. makes no claims, nor does it

intend its products to be used in street driven vehicles. Spohn Performance, Inc. reserves the right to

make changes in design or add to or improve on their product without incurring any obligation to install

the same on product previously manufactured. The Buyer agrees to indemnify and hold Spohn

Performance, Inc. harmless from any claim, action or demand arising out of or incident to the Buyer’s

installation or use of products purchased from Spohn Performance, Inc.

INSTALLATION INSTRUCTIONS

1. Begin by jacking up the front of the vehicle and then place jack stands under the

frame to safely support the vehicle. The front wheels need to be off of the ground.

2. Remove both front wheels using a 22mm deep socket.

3. On The Driver's Side Only: Using an 18mm socket or wrench, loosen the three (3)

nuts from the studs on the top strut mount (See Picture 1 Below).

4. Using a 15mm wrench or socket, remove both bolts from the lower strut mount's t-bar

to lower a-arm connection. Remove both of the nut clips from the top of the strut's

lower t-bar mount using a flat screw driver (See Picture 2 Below).

5. Using an 18mm socket or wrench, remove the three (3) nuts from the studs on the

top strut mount that you loosened in Step 3 above (See Picture 1 Below).

6. Remove the strut from the vehicle (See Picture 3 Below).

7. Install the supplied 1/2” thick round spacer plate on top of the upper strut mount (See

Picture 4 Below).

8. With the 1/2” thick spacer plate in place, reinstall the strut using three (3) of the

supplied 10mm flanged locking nuts. Make hand tight only at this time.

9. Press down on the lower a-arm and/or use a pry bar and place two (2) of the 1/2”

thick black powder coated lower t-bar spacers between the t-bar and the lower a-arm.

Align the holes and install the factory mounting bolts from underneath. Install two (2)

of the supplied 10mm flanged lock nuts from the top. Using a 15mm socket and

wrench torque both bolts to 35 ft./lbs. (See Pictures 5 & 6 Below)

10. Using a 15mm socket torque the three (3) 10mm flanged locking nuts on the upper

strut mount that you installed in Step 8 above to 35 ft./lbs. (See Picture 1 Below)

11. Repeat Steps 3-10 on the passenger's side of the vehicle.

12. Reinstall both front wheels and fully tighten the lug nuts using a 22mm deep socket.

13. Jack up the front of the vehicle and remove both jack stands. Safely lower the vehicle

to the ground.

14. Installation is complete. You now need to have a front end alignment completed by a

professional alignment shop. Factory front alignment specifications are recommended.

1 2 3 4

Résumé du contenu

Page 1 - Spohn Performance, Inc

Spohn Performance, Inc. 494 E Lincoln Ave Myerstown, PA 170671-888-365-6064 www.spohn.netPart# GM07-1500-FLK – 2.0” Front Leveling Lift Kit2007-201

Page 2 - Picture 2

Picture 1Picture 22

Page 3 - Picture 4

Picture 3Picture 43

Page 4 - Picture 6

Picture 5Picture 64

Modèles reliés GM14-1500-FLK

Commentaires sur ces manuels

Pas de commentaire

Spohn GM07-1500-FLK Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la voiture Spohn GM07-1500-FLK. Spohn GM07-1500-FLK User Manual Manuel d'utilisatio

Résumé du contenu

Modèles reliés GM14-1500-FLK

Commentaires sur ces manuels

Produits connexes et manuels pour Pour la voiture Spohn GM07-1500-FLK